Krisda SuchivaSauvarop BualekPranee PhinyocheepLa-oongtip Srichantamit2024-09-032024-09-03199119912024Thesis (M.Sc. (Polymer Science))--Mahidol University, 1991https://repository.li.mahidol.ac.th/handle/20.500.14594/100791Polymer Science (Mahidol University 1991)The objective of the present studies is to make further contribution to the knowledge of the effects of the non-rubber substances on the cure behavior, structures and propeties of natural rubber vulcanisates, with the view to reduce inconsistency of natural rubber. Five types of NR samples were prepared for this study, viz acid coagulate NR (ANR), whole NR (WNR) acetone-extrocted NR (ENR), deproteinised NR (DPNR and purified NR (PNR). The results showed that ANR sample showed the largest variations in cure behavior, while WNR and PNR samples exhibited relatively consistent vulcanisation properties. The results confirmed that non-rubber compounds have accelerating effect on vulcanisation reactions of NR. Therefore, exact control of the amount of these non-rubbers in the NR sample must be exercised if variation in the cure behaviour of NR is to be reduced. Complete removal of the non-rubbers (purified NR sample) or leaving them intact (whole NR sample) might provide alternative means for solving the inconsistency problem of NR. Study on the effects of non-rubbers on the network structures of NR vulcanisates showed that non-rubber compounds although had obvious influences on the cure time of NR, have no effect on the types and amounts of crosslinks farmed in the CV Vulconisate system cured by using CBS as accelerators. Thus the physical propreties were essentially unchanged. However, for the EV system, the absence of non-rubbers caused uniform distribution of mono-, di-, polysulphidic crosslinks. Although strength properties of these rubber vulconisates remained largely unchanged, the spread out of crosslink type resulted in improvement of flex-cracking properties observed for DPNR and PNR.xi, 82 leaves : ill.application/pdfengผลงานนี้เป็นลิขสิทธิ์ของมหาวิทยาลัยมหิดล ขอสงวนไว้สำหรับเพื่อการศึกษาเท่านั้น ต้องอ้างอิงแหล่งที่มา ห้ามดัดแปลงเนื้อหา และห้ามนำไปใช้เพื่อการค้าRubberVulcanizationMaster ThesisMahidol University